Product ID:MIL-A-5540B TYPE III
MSDS Date:10/03/1997
FSC:8040
NIIN:00-515-2245
Status Code:A
MSDS Number: CLNDP

TACC INTERNATIONAL CORP

AIR STATION INDUSTRIAL PARK
ROCKLAND, MA 02370
US

Emergency Phone: 800-424-9300

Info Phone: 781-878-7015

Preparer: ERNEST CARTER

Cage: 0HZU1

TACC INTERNATIONAL CORP

ROCKLAND, MA 02370 US

Telephone: 781-878-7015

Cage: 0HZU1

HEXANE

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 1800 MG/M3;500 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Effects of Overexposure:INHALATION: SIGNS OF OVEREXPOSURE COULD BE
HEADACHE, DIZZINESS, NAUSEA, UPPER RESPIRATORY DRYNESS OR
IRRITATION.DROWSINESS , MENTAL DEPRESSION OR NARCOSIS, DIFFICULTY
IN BREATHING. CHRONIC EFFECTS OF OVEREXPOSURE TO SOLVENT VAPORS
COULD LEAD TO PERMANENT EFFECTS TO THE NERVOUS SYSTEM, BODY
ORGANS, OR THE BRAIN. USE WITH ADEQUATE VENTILATION. EYES:
IRRITATION. SKIN: REMOVAL OF SKIN OILS, IRRITATI ON.DERMATITIS,
EVEN SENSITIZATION WITH LONG OVEREXPOSURE. INGESTION: MAY BE
HARMFUL OR FATAL IF SWALLOWED.

First Aid:INHALATION: GET FRESH AIR,IF NECESSARY CALL PHYSICIAN. SKIN:
WASH WITH MILD SOAP AND WATER, APPLY A MILD CREAM. EYES: FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. INGESTION: CALL POISON CENTER
IMMEDIAT ELY.

Flash Point Method:TCC
Flash Point:=-17.6C, 0.F
Lower Limits:1.1%
Upper Limits:7.5%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
FOG.
Fire Fighting Procedures:AVOID BREATHING SMOKE. USE AIR SUPPLIED RESCUE
EQUIPMENT FOR ENCLOSED AREA. WATER TENDS TO SPREAD BURNING LIQUID
IF LARGE AMOUNTS USED.
Unusual Fire/Explosion Hazard:FLAMMABLE. VAPORS MAY IGNITE EXPLOSIVELY
AND/OR CAUSE FLASH FIRES. ELIMINATE SOURCES OF IGNITION. NO
SMOKING. USE ADEQUATE CROSS VENTILATION SUFFICIENT TO REMOVE ODOR
OF SOLVENT AND VAPORS. ELECTRICAL LY GROUND ALL CONTAINERS DURING
TRANSFER.

Spill Release Procedures:SMALL QUANTITIES MAY BE ABSORBED INTO AN
APPROPRIATE ABSORBENT. FOR LARGE SPILLS SEE SECTIONS 1V, V111, AND
IX.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AT 60-95 DEGREES F AND OUT OF THE SUN. USE ADEQUATE
VENTILATION TO AVOID BREATHING VAPORS WHEN COVER IS REMOVED. GROUND
ALL EQUIPMENT WHEN HANDLING FLAMMAB LE SOLVENTBORNE MATERIALS.

Respiratory Protection:IF VAPORS EXCEED TLV USE SELF CONTAINED ORGANIC
MASK NIOSH APPROVED.
Ventilation:SUFFICIENT TO KEEP WORKROOM CONCENTRATION BELOW TLV.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES OR FACE SHIELD.
Other Protective Equipment:BARRIER CREAM FOR SENSITIVE SKIN.
Supplemental Safety and Health

Boiling Pt:B.P. Text:149-231 DEG F
Vapor Density:HEAVIER
Spec Gravity:0.85474
VOC Grams/Liter:7.12
Evaporation Rate & Reference:FASTER THAN N-BUTYL
Appearance and Odor:NEUTRAL, AROMATIC ODOR
Percent Volatiles by Volume:83.0%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. STRONG ACIDS AND BASES.
Stability Condition to Avoid:FIRE, SPARKS, STATIC ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

State Regulatory Information: